smoke coming out of side of smoker

parrottgary · October 23, 2009, 08:27:24 AM

i have a problem ,i have more smoke coming out of the side of my smoker than is actually going in the smoker.i thought about putting gasket material between the bradley and the smoker but would like to know is there a reason this could be happening thanks

classicrockgriller · October 23, 2009, 08:35:34 AM

Is your vent closed?

OU812 · October 23, 2009, 08:36:32 AM

Sounds like you have your vent on the top closed to much.

You should have it at least half way open, if not more, all the time

OU812 · October 23, 2009, 08:38:34 AM

Oh ya, welcome to the fun of smoking.

Also try to keep your smoker out of the wind.

Tenpoint5 · October 23, 2009, 08:47:11 AM

As the others have questioned where do you have your vent? As most new Bradley smokers Think, Yes we have all done this, More Smoke Is Better, so I will Close the vent to get more smoke. This is in fact a bad thing. As you have noticed the smoke IS going to find a way out. The way out is the Smoke Generator opening. This escape route for the smoke will eventually destroy your SG. As almost everyone will tell you, you should keep your top vent open AT A MINIMUM 1/4 open. most run theirs 3/4 to full open. Even after the smoke is done ( You shouldn't need more than 1.5-3 hours of smoke on anything depending on your tastes) you should still leave your vent open. By closing the vent you trap the moisture inside the cabinet causing a reduction in heat inside the cabinet.

Also Welcome Aboard Gary!! Enjoy the forum.

parrottgary · October 23, 2009, 08:57:55 AM

thanks alot guys,will try your ideas this weekend

KyNola · October 23, 2009, 09:11:16 AM

10.5 is 100% correct. Smoke backing up in the generator is a sure sign that the vent needs to be opened more. Otherwise it is going to destroy your generator. Keep opening the vent until you no longer see any smoke coming from around the generator.

KyNola

pensrock · October 23, 2009, 09:16:41 AM

Welcome to the forum, the others got you covered. Keep the vent open, mine is almost always wide open and never more than 1/2 closed.

FLBentRider · October 23, 2009, 09:38:06 AM

W E L C O M E to the Forum parrottgary

muzzletim · October 23, 2009, 11:32:38 AM

I remember my first time with the Bradley I had smoke coming out everywhere, then I smoked for 8 hours besides! Wish I had known about the forum then! I agree open up the vent!!!

Quarlow · October 23, 2009, 03:35:05 PM

Welcome to the forum Parrotgary. You'll be alright, just stick with us. If the smoke is coming out the side, that just means you are new to this. We all did it.

ArnieM · October 24, 2009, 03:40:33 PM

Welcome PG. 10.5 gave a very good explanation. Very early on, I figured closing the vent most of the way would keep in the smoke and heat. It sounded logical but was totally wrong. It can lower the cabinet temp, really. And you can wind up with condensation dripping on your food - not Good Eats.

Also early on, I had thought about making a gasket, maybe 1/32 material, between the SG and the cabinet. But, it hasn't been necessary after learning how to use the smoker properly.

As others have mentioned, I usually go 3/4 to full open no matter what I'm smoking.

JGW · October 24, 2009, 10:28:44 PM

I'll second everyone's replies. I always run the vent at least 1/2 open, and often times full open.

Hopefull Romantic · October 25, 2009, 02:28:44 AM

After all that has been said, you should know that, in this forum, you are in good hands.

Welcome aboard Parrottgary.

HR